skip to main content

So losing fuel is normal...

16 years ago

From what I've learned about small engine powered equip't I can expect to see the puddle of gas from my tractor until I install a shutoff? I put the tractor in my garage for the first time ever and really noticed the leak for the first time. The carburetor is actually a recently replaced Kohler part and replacing it didn't seem to change the rate of the leak. (My CV490 has the fuel shutoff solenoid) Anything else I should know about this Craftsman POS (hey, it was cheep)?

Sort by:Oldest

Comments (9)

bill_kapaun
16 years ago
A fuel shut off solenoid has nothing to do with fuel leaking OUT of the carb. It's simply a plunger that shuts off fuel in the Main Jet, preventing fuel from being drawn into the engine to prevent back/afterfire when shutting the engine off.
A GOOD carb "shouldn't" leak.
mownie
16 years ago
A fuel shutoff valve is recommended if you have a "gravity feed" fuel system (tank higher than carb) to eliminate the chance of fuel flowing through the carb when the engine is not running. As bill stated "a good carb doesn't leak". Fuel might flow through a "good carb" if the machine is parked on an unlevel surface because that can defeat the ability of the float to shut the needle valve which controls the flow of fuel into the carb and keeps it at a specific height or level in the bowl. Machines that require a fuel pump (carb higher than tank) to move the fuel from the tank to the carb are not usually affected by this unless they are parked with the fuel tank elevated higher than the carb. Equipping your fuel line with a cutoff valve is good insurance against one of those things that ain't supposed to happen. No, it is not "normal" to lose fuel. It's unfortunate and hazardous.
Related Discussions
Craftsman LT1000 loses power
Q
Comments (8)
Well, now that we know for sure the problem is not related to the deck..... When you had the carb apart, did you check the operation of the fuel solenoid to make sure it operates fully when it is supposed to? You can check this using a 12 volt power source (tractor battery). Ground the fuel solenoid body to a metal surface of the tractor and touch the fuel solenoid wire to the battery positive cable. The plunger on the solenoid should "pull in" about 1/8" to 3/16" and stay there til you disconnect the hot wire or the ground. If the plunger does not move, you might nudge it with your finger. It should pop out when you take away the 12 volt source. It might be a good idea now to go ahead and check the valves, but if it is a problem whith the valves causing this, I don't think a simple adjustment is going to be the answer. In the process of checking the valves, you need to turn the engine by hand with the valve cover off and watch both valves as they open and close. If one valve seems to just barely move to open (compared to the other valve), you may have a faulty camshaft. There have been reports of camshaft lobes wearing on certain of the 31 Series B&S engines.
...See More
Craftsman GT5000 Kohler CV22 engine loses power intermittently
Q
Comments (1)
The model and spec # both are really needed to see what is needed to see. Unfortunately, this isn't referenced under the Sears model in your case. Some of these have an accelerator pump - mounted on the side of the carb bowl w/ 3 screws. Sometimes the diaphragm fails in these. Temp plugging the small line to it and seeing if it runs w/ an appreciable difference can help. Coil/ harness/ SAM if applicable can create intermittent runablity issues as well.
...See More
Normal Water Evaporation for So Cal?
Q
Comments (3)
with the current weather that's about normal. He's full of baloney. Fill the bucket to the rim and set it on the top step of the pool. Compare both for equal loss. Turn off any water features and run the pool 24 hours. Re-mark the levels and do it again with everything off for 24 hours. Are you having issues with chemistry. ie, low to zero chlorine, low TDS?
...See More
I'm losing my mind! All induction cooktop or MY preference: with gas?
Q
Comments (14)
Thank you ALL for your responses. Each has helped clarify add'l thoughts I've had and brought up new ones! I THINK I've made a decision about what I need to do. As of this moment, I'm going to buy a 30" black glass induction cooktop - 4 burners. When I want to use one of my non-induction pans, I'm going to use a heavy-duty gas, 12,000 BTU portable unit that runs on Butane (1 hr. of continuous high BTUs usage; 2-3 hrs. for medium)! It's clear that my needs for those won't be often, but it WILL solve most of my issues that were bothering me and I won't have to give ALL of my favorite pans away that I so feared. And I'll still have access to BOTH induction AND gas (my original duel-fuel passion)! The reviews for this particular 12,000 BTU gas unit were outstanding and it's cost is less than $50 for the privilege. I was considering the Bosch Flexinduction or the highly praised (by reviewers) Frigidaire FGIC 3067MB. But, now I've noticed here the Bosch 800 being discussed for less $$ than the Flex if one doesn't need the flexible pods (which I don't, really). Frigidaire has about all the goodies EXCEPT individual burner timers at around $1100 or so with just terrific reviews on amazon - an amazing price point. Can anyone point out some detriments of these three that I may not have noticed or be aware of? What would all of us unknowing people do without all your input and kind help??
...See More
walt2002
16 years ago
"I can expect to see the puddle of gas from my tractor until I install a shutoff? "

That is the least of your problem. If you are seeing a puddle of gas there is a good chance that the engine oil is also being contaminated with gas.

"(My CV490 has the fuel shutoff solenoid) "

That does not shut off gas getting to the carb. and leaking.

Walt Conner
grassmaster
16 years ago
Sounds like you have a bad carburetor (still) or else the fuel leak is coming from somewhere else.

Regardless, it should not leak, and you should not have to shut the fuel off.
walt2002
16 years ago
"Regardless, it should not leak, and you should not have to shut the fuel off."

You are talking in the "perfect world" in reality he does need an inline shutoff valve.

Walt Conner
kubotabx2200
16 years ago
Hmm -- well, my 19 year old Troy-bilt mower lacks a fuel shutoff -- it doesn't leak fuel and never has.

The 10 HP Subaru Robin engine in the Powermate generator has a fuel shutoff which is nice to turn off and run the engine dry for storage. But it doesn't leak any fuel either.

Carburetors are not supposed to leak fuel. It is a defect and an extreme fire hazard.
rcmoser
16 years ago
Yep, you shouldn't of brought one with a Kohler (which puts the Piece of "S") in the Craftman. IMO thats why you got it cheap, it probably been leaking for a long time.
"good chance that the engine oil is also being contaminated with gas". This could be a good thing!?! Clean all the sludge out due to no oil changes". Fix the POS engine then later when lack of maintenance well break something else you can call the rest of the LT a POS.
edsacre
16 years ago
cowboy,
whatever you do to fix it & it should be fixable, be sure your insurance is up to date
jimc_vt
16 years ago
Smelly, fire hazard....you need to get it fixed correctly ! Jim

Related Stories

ARCHITECTURE What’s Fueling Austin’s Edgy Modern Architecture?

By Mitchell Parker

A look at the blossoming design scene in Texas’ capital city — and what’s behind all the experimentation

EARTH DAY The Case for Losing the Traditional Lawn

By Benjamin Vogt / Monarch Gardens

Work less, help the environment and foster connections by just saying no to typical turf

MOST POPULAR 7 Ways to Design Your Kitchen to Help You Lose Weight

By Mitchell Parker

In his new book, Slim by Design, eating-behavior expert Brian Wansink shows us how to get our kitchens working better

BEFORE AND AFTERS See 6 Yards Transformed by Losing Their Lawns

By Annie Thornton

Wondering whether a turf lawn is the best use of your outdoor space? These homeowners did, and they found creative alternatives

DECORATING GUIDES Lose It: How to Get Rid of a Mattress

By Vanessa Brunner

Updating your bedroom? Here's how to donate, reuse or recycle that mattress — and keep it out of the landfill

DECORATING GUIDES No Neutral Ground? Why the Color Camps Are So Opinionated

By Vanessa Brunner

Can't we all just get along when it comes to color versus neutrals?

LIGHTING So You Bought a Cave: 7 Ways to Open Your Home to Light

By Alison Hodgson

Make the most of the natural light your house does have — and learn to appreciate some shadows, too

GARDENING FOR BUTTERFLIES 3 Ways Native Plants Make Gardening So Much Better

By Benjamin Vogt / Monarch Gardens

You probably know about the lower maintenance. But native plants' other benefits go far beyond a little less watering and weeding

KITCHEN DESIGN So Over Stainless in the Kitchen? 14 Reasons to Give In to Color

By Becky Harris

Colorful kitchen appliances are popular again, and now you've got more choices than ever. Which would you choose?

HOUSEKEEPING 10 Problems Your House May Be Trying to Show You

By Mitchell Parker

Ignore some of these signs and you may end up with major issues. We tell you which are normal and which are cause for concern

Sponsored

More Discussions

Mower Blade rotation

1