skip to main content

What's the Life of a Car's Complete Electronic System?

19 years ago

Does the electronic system which runs most of the car (oxygen sensor, airbag sensors, automatic brake adjusters, open door sensors, auto climate control, fuel injection system, spark control, EGR, computerized this and that, instrumentation and computer) die or begin to die of pure old age regardless of mileage? If so, what age might that be?

Sort by:Oldest

Comments (3)

gary__
19 years ago
I've been driving a 1987 corvette daily for the last 3 years. It's got all that stuff you mentioned except air bags. The only thing that failed so far in the 45k miles I've driven it was the MAF burn off relay, which was a $10 part at NAPA. I splurged and replaced both MAF relays at the same time for $20.

I doubt there's a definitive answer to your question.
steve_o
19 years ago
I agree with gary__. There are so many variables: the design of the components (and where/how they are installed in the car); their initial quality; their upkeep, how you drive; and so on.

Electronics in a car that is garaged most of the time should last longer because they're exposed to fewer extreme shifts in temperature. A car that "lives" in the country likely will have its wiring exposed to less corrosive elements (smog, etc.), which could help it last longer. A car that is frequently exposed to high humidity (especially near salt water) suffers more than a car that is used in a dry area -- though that car runs the risk of dust causing problems or heat retention. People who do only short-hop driving run the risk of problems with their emissions equipment.

On a purely-electronic level, the chips and capacitors and circuit boards are fairly inert. They can last for several decades; certainly longer than 10.

Wiring -- especially rubber and vinyl -- will deteriorate over time because of the heat and flexure that is part of a running car -- though it will deteriorate more slowly in a car that isn't driven much or isn't driven in extreme conditions. Tire manufacturers are recommending that tires be replaced every six years or so regardless of the mileage on them; I would guess that hoses/belts/rubber components under the hood have a similar lifespan. The timing belt in my car -- a reinforced rubber belt -- should be replaced every 100,000 miles or every five years, whichever comes first. Repetitive motions also can damage electronics-related components, like trunk-light wiring, depending on design.

Then there's the question of what you can live without. A failed open-door sensor or a flickering trunk light is a nuisance, but certainly not a showstopper.
Related Discussions
Trane XE1000 heat pump system suddenly is completely dead
Q
Comments (12)
I got my system (Trane XE1000 Heat Pump with Aux. Heat) up and running with the new thermostat. While the aesthetics are much better and the programming is much easier than my old thermostat (CT3611), one thing that I noticed this AM is that this thermostat seems much more likely to kick in the Aux Heat. I have a 2 system house with a gas furnace in the basement. I'd like the heat pump to be much less aggressive with turning on the aux heat and rely a little more on the gas furnace to help bring the temperature up in the house. I found a setting (580 or 680) which states adjusts an "aggressiveness" factor for the aux heat but it still seems to kick on quickly. My old thermostat had a feature called something like adaptive heat recovery which calculated how long it took to heat the house back up and adjusted itself to just turn on earlier if it takes longer to warm the house. Granted, I didn't sit around the house all day watching the thermostat to count the hours the aux heat was on or off, but it seems like it was less. Does this new thermostat do the same thing in terms of trying to minimize aux. heat use? Is it just a matter of time before the thermostat learns my house and heating patterns? Does having the external temperature sensor help? Thanks, David
...See More
Life Expectancy of an HVAC System?
Q
Comments (14)
I don't think there is any sure way of telling how old a system gets before it needs replacing. There is for when you "should" though. It's time when the system is just to expensive to operate or maintain and no longer is trustworthy. I've seen old noisey, rusty, ugly systems that I thought would die anytime, run another 5 years or so- amazing! But then I've seen systems I thought would last many more years go out sooner than normal. Older systems can last last 30 years, the later systems seem to average 12-18 years. Competition for price and efficiency has driven makers to use thinner copper and materials, though compressors are much better now than years past with the scroll technology. A good proffessional installation is utmost important if the life of the system is a concern along with yearly service. The time to replace a system is BEFORE it goes out completely and is in the age range of 12-18 years.Some sooner. If you don't trust your HVAC company to deal honestly with you, then you need to shop around, but remember- picking the company that tells you what you want to hear, may not be the right choice either.
...See More
free furnace with complete system install
Q
Comments (15)
Our winters are pretty mild here most of the time. Our temps are really no different than Dallas. The only difference is that Dallas has a slightly shorter winter season.We don't have much weather below freezing. To me that 14 for heating seems very low. Our big concern is the AC. It is really not unusual to have temps above 100 and we have been known to have 30 straight days or more over 100. It does not cool off at night. Peak heat days will have lows around 85. I changed the summer temps to 72 and 98 and winter to 72 and 14. I only have 4 people. Maybe that should be higher? And for appliances, do I include the furnace and compressor? I used 6 appliances, kitchen and washer and dryer. That gave me 41116 BTU's for cooling and 33748 Btu's for cooling. Sensible load 37495.
...See More
Completely OT-British vs. US cars
Q
Comments (14)
Very few people in the United States even learn how to drive with a manual transmission anymore, and very few of them are even manufactured these days. Manuals used have points of superiority - more control in dangerous weather, lower gas consumption, and cheaper to buy. Technology seems to have eliminated these advantages. I have driven a manual, but it was many years ago and I never did it enough to gain ease and genuine skill. There was an incident I will not go into, but I made a vow to never drive one again. I never have. We are moving in the opposite direction, in fact. I see driverless cars on the road from time to time. Google headquarters are in the next town over and we see driverless cars being tested. (I got to sit in one once at the Computer History Museum, very cool.) I welcome this. I see healthy older people forced to give up their independent living and leave their homes merely because they can no longer drive. In many places it is simply not possible to live without a car. There is no public transportation available. Certainly this is true in rural areas, but it is also widespread in suburbs. This very nearly happened to my father, though in the end my sister moved in with him. Moving would have broken him, so I'm glad didn't come to that.
...See More
mxyplx
Original Author
19 years ago
OK. I'll keep it. I've begun to let some things slide. Prolly change the belt though whether it needs it or not.

Related Stories

ORGANIZING Want to Streamline Your Life? Get a System

By Glamour Nest

Reduce stress and free up more time for the things that really matter by establishing specific procedures for everyday tasks

GREEN BUILDING Houzz Tour: Going Completely Off the Grid in Nova Scotia

By Mitchell Parker

Powered by sunshine and built with salvaged materials, this Canadian home is an experiment for green building practices

CONTRACTOR TIPS Your Complete Guide to Building Permits

By Matt Clawson

Learn about permit requirements, the submittal process, final inspection and more

MOST POPULAR Three Magic Words for a Clean Home and a Better Life

By Alison Hodgson

Not a natural tidying and organizing whiz? Take hope in one short phrase that can change your life forever

TASTEMAKERS New Series to Give a Glimpse of Life ‘Unplugged’

By Stacy Briscoe

See what happens when city dwellers relocate to off-the-grid homes in a new show premiering July 29. Tell us: Could you pack up urban life?

LIFE 11 Tiny Tricks That Make Life a Tad Better

By Natasha Saroca

Make these small tweaks to your home and daily routine, and life will be easier, less rushed and maybe healthier too

LIFE 10 Smart Organizing Ideas That Make Life Easier

By Laura Gaskill

Rethink where and how you store household basics, from bills to baking supplies, to buy some time and save some headaches

MOST POPULAR Organized From the Start: 8 Smart Systems for Your New House

By Laura Gaskill

Establishing order at the outset will help prevent clutter from getting its foot in the door

GREAT HOME PROJECTS How to Add a Radiant Heat System

By Mariana Pickering (Emu Building Science)

Enjoy comfy, consistent temperatures and maybe even energy savings with hydronic heating and cooling

HOME TECH Does Your Home Need an Operating System?

New technologies hope to unify the lawless frontier of home-automation products. Would they work for you?

Sponsored